Occupational Health Risks Associated with Exposure to Particulate Matter; PM2.5, PM10, Formaldehyde (HCHO) and other Gases in Wastewater Treatment Plants
DOI:
https://doi.org/10.47672/ajes.2741Keywords:
Occupational, Health (I18), Risks exposure (J81), PM2.5 (Q53), PM10 (Q53), formaldehyde (Q53), wastewater (L95), pollution (Q53)Abstract
Purpose: This research assessed the occupational exposure associated with particulate matter (PM2.5 and PM10), formaldehyde vapors (HCHO) and carbon dioxide (CO2) in a wastewater treatment plant in Nairobi, Kenya. The determined airborne pollutants levels were analyzed to identify potential health risks on the Plant's workers.
Materials and Methods: Air quality measurements were conducted across six locations for a period of three months using a hand-held air quality monitoring device, Temptop M2000 which has high precision formaldehyde, laser particle and carbon dioxide sensors. Three samples were collected at each location and this data analyzed using Statistical software. Observations were also made on the prevalent activities in each location and used in data interpretation.
Findings: PM2.5 and PM10 levels exceeded WHO guidelines, with the highest concentrations recorded at the pond (11.60±1.57 µg/m³) and inlet works (17.41±1.55 µg/m³), respectively. CO2 was highest in office areas (571.33±207.1 ppm), while HCHO peaked at the inlet (0.81±0.18 mg/m³), surpassing the 0.08 mg/m³ WHO guideline. Elevated temperatures (mean 27.98±2.36°C) were linked to increase PM2.5, while higher relative humidity (mean 44.13±5.75%) correlated with greater concentrations of PM10, HCHO, and CO2. A one-sample t-test confirmed significantly elevated PM2.5 and HCHO levels. The levels for all contaminants were highest during the morning and dropped as the water volumes reduced from in the evening. Hazard quotients indicated substantial health risks, particularly for HCHO at HQ=5.125, suggesting potential respiratory, cardiovascular, and carcinogenic effects. Although the cancer risk from HCHO exposure was found to be minimal, chronic exposure may pose long-term health effects.
Unique Contribution to Theory, Practice and Policy: This study recommended enhanced worker protection through PPE provision, routine medical check-ups, and adherence to national air quality regulations to mitigate risks. Effective hazard management strategies are also crucial for safeguarding health within wastewater treatment environments.
Downloads
References
Agency for Toxic Substances and Disease Registry. (2020). Guidance for inhalation exposures. U.S. Department of Health and Human Services, Public Health Service. https://wwwn.cdc.gov/TSP/MMG/MMGDetails.aspx?mmgid=1&toxid=1#tab4
California Air Resources Board. (2025). Inhalable particulate matter and health (PM2.5 and PM10). https://ww2.arb.ca.gov/resources/inhalable-particulate-matter-and-health
Centers for Disease Control and Prevention. (2015). Hierarchy of controls. National Institute for Occupational Safety and Health. https://www.cdc.gov/niosh/hierarchy-of-controls/about/index.html
Dannoun, Y., & Nouban, F. (2021). Occupational health hazards and risk assessments in wastewater treatment plant. International Journal of Advanced Engineering, Sciences and Applications, 2(2), 21-25. https://doi.org/10.47346/ijaesa.v2i2.83
Glavaš, V., Čurić, M., Pehnec, G., & Bešlić, I. (2020). Ionic composition of PM2.5 particle fraction at a coastal urban background site in Croatia. Atmospheric Pollution Research, 11(12), 2202–2214. https://doi.org/10.1016/j.apr.2020.07.004
Health Effects Institute. (2022). Health effects of air pollution in East Africa: A research agenda. https://www.healtheffects.org/sites/default/files/health-effects-of-air-pollution-in-east-africa.pdf
Intergovernmental Panel on Climate Change. (2013). Climate change 2013: The physical science basis. Cambridge University Press. https://library.wmo.int/records/item/41813-climate-change-2013-the-physical-science-basis
International Agency for Research on Cancer. (2012). Formaldehyde. A review of human carcinogens: Part F: Chemical agents and related occupations (pp. 401–435). https://doi.org/10.1016/s1470-2045 (09)70358-4
Jacob, D. J., & Winner, D. A. (2009). Effect of climate change on air quality. Atmospheric Environment, 43 (1), 51–63. https://doi.org/10.1016/j.atmosenv.2008.09.051
Jacobson, T. A., Kler, J. S., et al. (2019). Direct human health risks of increased atmospheric carbon dioxide. Nature Sustainability, 2. 691–701. https://doi.org/10.1038/s41893-019-0323-1
Kenya Law. (2022). Environmental Management and Co-ordination (Air Quality) Regulations, 2013 Legal Notice No. 34. https://new.kenyalaw.org/akn/ke/act/ln/2014/34/eng@2022-12-31
Khamsai, C., et al. (2023). PM2.5 and cardiovascular diseases: State-of-the-art review. International Journal of Cardiology: Cardiovascular Risk and Prevention, 19, 200217. https://doi.org/10.1016/j.ijcrp.2023.200217
Lei, W., et al. (2017). Formaldehyde (HCHO) as a hazardous air pollutant: Mapping surface air concentrations from satellite and inferring cancer risks in the United States. Environmental Science & Technology, 51(10), 5650–5657. https://doi.org/10.1021/acs.est.7b01356
Marsh, G. M., Morfeld, P., Zimmerman, S. D., et al. (2016). An updated re-analysis of the mortality risk from nasopharyngeal cancer in the National Cancer Institute formaldehyde worker cohort study. Journal of Occupational Medicine and Toxicology, 11(8). https://doi.org/10.1186/s12995-016-0097-6
Oluoch, I., & Ndeda, H. O. J. (2017). Effect of occupational safety and health awareness on work environment in the water service industry within Kisumu County, Kenya. IOSR Journal of Environmental Science, Toxicology and Food Technology, 11(6), 35–41. http://www.iosrjournals.org
Peng, W.-X., et al. (2022). A review of plants formaldehyde metabolism: Implications for hazardous emissions and phytoremediation. Journal of Hazardous Materials, 436, 129304. https://doi.org/10.1016/j.jhazmat.2022.129304
Pope, C. A., & Dockery, D. W. (2006). Health effects of fine particulate air pollution: Lines that connect. Journal of the Air & Waste Management Association, 56(6), 709–742. https://doi.org/10.1080/10473289.2006.10464485
Ramalho, R. S. (2013). Introduction to wastewater treatment processes (2nd ed.). Academic Press. ISBN: 978-0-08-092533-5
Sharma, S. K., & Mandal, T. K. (2023). Elemental Composition and Sources of PM₂.₅ in Delhi, India. Bulletin of Environmental Contamination and Toxicology, 110, Article 60. https://doi.org/10.1007/s00128-023-03707-7
Silva, R. & Mendes, D. (2019). Occupational exposure to formaldehyde in Brazilian wastewater plants. Brazilian Journal of Occupational Medicine, 17(1), 45–52. https://doi.org/10.1016/j.envres.2019.108740
Srinandini, C., et al. (2011). Effect of temperature and humidity on formaldehyde emissions in temporary housing units. Journal of the Air & Waste Management Association, 61(6), 689–695.
Sustainable Sanitation Alliance (SuSanA). (2021). Occupational exposure to sewer gases among informal sanitation workers in Nairobi, Kenya. https://sanitationworkers.susana.org
Tucci, F. J., & Rosenzweig, A. C. (2024). Direct methane oxidation by copper- and iron-dependent methane monooxygenases. Chemical Reviews, 124(3), 1288–1320. https://doi.org/10.1021/acs.chemrev.3c0072700
U.S. Environmental Protection Agency. (2024). Integrated Risk Information System (IRIS): Toxicological review of formaldehyde (inhalation). EPA/635/R-24/162cF.
United Nations Environment Programme. 2021). Actions on air quality: A global summary of policies and programmes to reduce air pollution. https://www.unep.org/resources/report/actions-air-quality-global-summary
United States Environmental Protection Agency. (2019). our nation’s air: Status and trends through 2019. https://gispub.epa.gov/air/trendsreport/2019
United States Environmental Protection Agency. (2023, October 11). Health and environmental effects of particulate matter (PM). https://www.epa.gov/pm-pollution/health-and-environmental-effects-particulate-matter-pm
Viteri, G., Aranda, A., Díaz-de-Mera, Y., Rodríguez, A., Rodriguez-Fariñas, N., & Rodríguez, D. (2025). Assessment of airborne pollutants in wastewater treatment plants. Environmental Science and Pollution Research, 1-15.
Wambebe, N. M., & Duan, X. (2020). Air Quality Levels and Health Risk Assessment of Particulate Matters in Abuja Municipal Area, Nigeria. Atmosphere, 11(8), 817. https://doi.org/10.3390/atmos11080817
Wei, S. (2021). Aerobic oxidation of methane to formaldehyde mediated by Crystal-O over gold-modified tungsten trioxide via photocatalysis. Applied Catalysis B: Environmental, 283, 119661. https://doi.org/10.1016/j.apcatb.2020.119661
Widiana, D. R., et al. (2019). Air pollution profiles and health risk assessment of ambient volatile organic compounds above a municipal wastewater treatment plant, Taiwan. Aerosol and Air Quality Research, 19(2), 375–382. https://doi.org/10.4209/aaqr.2018.11.0408
World Health Organization. (2021). WHO global air quality guidelines: Particulate matter (PM₂.₅ and PM₁₀), ozone, nitrogen dioxide, sulfur dioxide and carbon monoxide. https://www.who.int/publications/i/item/9789240034228
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Mwenda Frankline Festus, Njogu Paul M., PhD, Karanja Benson H., PhD

This work is licensed under a Creative Commons Attribution 4.0 International License.
Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution (CC-BY) 4.0 License that allows others to share the work with an acknowledgment of the work's authorship and initial publication in this journal.